欣谕大型冻干机生产型食品冷冻干燥机高分子石墨烯真空冷冻干燥机XY-GY-1000上海水果冰冻干燥机
产品简介
详细信息
欣谕生产型冷冻干燥XY-GY-1000技术规格及配置
TECHNICAL SPECIFICATIONS
General Detail 总述 | |||
Sr. No. | Description 描述 | Specifications 规格 | |
1 | Mode 型号 | XY-GY-1000 | |
2 | Output (approx.) 产量（大约） | 1000KG | |
3 | Maximum ice capacity Z大捕冰力 | 1200kg | |
4 | Control 控制方式 | Microprocessor 微机处理 | |
5 | Dimension of unit (approx.) (L × W × H) (mm) 外型尺寸（大约）（长×宽×高） | 14500×2500×3500 (Final dimension based on design) （以Z终设计尺寸为准） | |
6 | Weight (approx.) 重量（大约） | 38,000kg | |
Chamber 冻干箱 | |||
1 | Chamber type 冻干箱外型 | Cylindrical 圆筒体 | |
2 | Maximum design pressure Z大设计压力 | 常压 | |
3 | Maximum design temperature Z大设计温度 | 常温 | |
4 | Finish 内部抛光度 | Ra≤0.5um (0.5Mircon) | |
5 | Validation port 验证孔 | Included 有（1个）位置箱体顶部 | |
6 | Viewing port 视镜 | Illuminated 带远射灯【广角】 | |
Number 数量 | 1 | ||
Location 位置 | Side 侧面 | ||
Dimension 尺寸 | DN200 (mm) | ||
7 | Material 材质 | ||
Internal 内部 | SUS 304 | ||
Insulation 保温 | polyisocyanurate foam 聚氨酯发泡材料 | ||
External cover 外部 | SUS 304 | ||
Door 箱门 | |||
1 | Finish 抛光度 | Ra≤0.5um (0.5Mircon) | |
2 | Viewing port 视镜 | Included 有 | |
Number 数量 | 1 | ||
Location 位置 | On height 1.5m (approx.) 高度1.5米（大约） | ||
3 | Open direction 开门方向(根据客户要求） | Right (face to door, hinge on right side) 右开（面对箱门，铰链在右） | |
4 | Open angle 开门角度 | More than 110o 大于110度 | |
5 | Gasket 密封圈 | O-shaped silicone rubber single gasket O型硅橡胶单密封 | |
6 | Locking arrangement 门锁方式 | Auxiliary manual handle 辅助手柄 | |
7 | Material 材质 | ||
Internal 内部 | SUS 304 | ||
Insulation 保温 | polyisocyanurate foam 聚氨酯发泡材料 | ||
External cover 外部 | 304 | ||
Shelves 板层 | |||
1 | Temperature range 温度范围 | -45~-50°C to + 80°C | |
2 | Temperature sensors (shelves) 板层温度探头 | 3 | |
Silicone oil inlet 导热油进口 | |||
Silicone oil outlet 导热油出口 | |||
3 | sensors 温度探头 | 3 | |
4 | Number of shelves 板层数 | 16+ 1(upper radiant shelf) （温度补偿板） | |
5 | Dimension (L × W × T) (mm) 板层尺寸（以设计为准） | 4000x1600x15 | |
6 | area (sq. m) 面积 | 102 | |
7 | Spacing (mm) 板间距 | 65 | |
8 | Hose of flexible connection 软管连接 | Welding 焊接 | |
9 | Finish 抛光度 | Ra≤0.5um (0.5Micron) | |
10 | Level 平整度 | ≤±0.5mm/m | |
11 | Material 材质 | SUS 304 | |
Condenser 冷凝器 | |||
1 | Condenser type 冷凝器外型 | Cylindrical 圆筒体 | |
2 | Viewing port 视镜 | Illuminated 带远射灯【广角】 | |
Number 数量 | 1 | ||
Location 位置 | Easily observe the whole inside condenser 容易观察到整个箱体内部 | ||
Dimension 尺寸 | DN200 (mm) | ||
3 | Final temperature J限温度 | -65°C~-70℃ | |
4 | Cooling time (+20 to -40°C) 制冷速度(空载) | ≤30 minutes (empty) | |
5 | Maximum design pressure Z大设计压力 | 常压 | |
6 | Maximum design temperature Z大设计温度 | 常温 | |
7 | Finish 抛光度 | Ra≤0.5um (0.5Mircon) | |
8 | Coiled pipe material 盘管材质 | SUS 304 | |
Internal 内部 | SUS 304 | ||
Insulation 保温 | polyisocyanurate foam 聚氨酯发泡材料 | ||
External cover 外部 | SUS 304 | ||
Shelf Heating / Cooling 板层升温/降温 | |||
1 | Circulation pump 循环泵 | ||
Brand 品牌 | DF | ||
Model 型号 | CDL65-1 | ||
Type 形式 | Centrifugal pump 离心式 | ||
Number 数量 | 1 | ||
Motor power 电机功率 | 5.5kW | ||
2 | Plate heat exchanger 板式热交换器 | ||
Brand 品牌 | Hexnovo | ||
Type 方式 | Sealed brazed stainless steel 不锈钢封蜂窝式 | ||
Number 数量 | 1 | ||
3 | Heater 电加热 | PID control PID 控制【双组电加热系统】 | |
4 | Maximum heating power Z大加热功率 | 24KW*4 | |
5 | Thermal fluid 导热介质 | Special heat conducting oil for freeze dryer 冻干机专用导热油 | |
6 | Shelf cooling time (+20°C to -40°C) 板层制冷速度(空载) | ≤60 minutes (empty) | |
7 | Heating rate 加热速度(大约) | 1°C/min (approx.) | |
Refrigerating System 制冷系统 | |||
1 | Compressor 压缩机 | ||
Brand 品牌 | RefComp 莱富康（意大利） | ||
Model 型号 | SW3L10500 | ||
Type 方式 | Two-stage 双级 | ||
Number 数量 | 2 | ||
Motor power 电机功率 | 78kW *2 | ||
2 | Refrigerant 制冷剂 | HFC-free R404A | |
Main refrigerating units 主要制冷元件 | |||
1 | Thermostatic expansion valve 热力膨胀阀 | Danfoss | |
2 | Solenoid valve 电磁阀 | Danfoss | |
3 | Service valve关断阀 | Denaline | |
4 | Safety valve安全阀 | Castel | |
5 | Capped valve顶盖阀 | Castel | |
6 | Sight glass视液镜 | Danfoss | |
7 | Water cooling condenser水冷凝器 | Teyi | |
8 | Oil separator 油分离器 | Fasike | |
9 | Gas-liquid separator 汽液分离器 | Fasike | |
10 | Filter 过滤器 | 滤壳Hongguo滤芯 ALCO | |
Vacuum System 真空系统 | |||
1 | Final vacuum J限真空 | ≤2.7×10 -2mbar | |
2 | Evacuation time 抽气速度 | ≤30minutes (1×103 mbar to 1×10-1 mbar) | |
3 | Vacuum pump 真空泵 | ||
Brand 品牌 | Baosi | ||
Model 型号 | BSV90 | ||
Type 方式 | OIL-rotary 油旋片式真空泵 | ||
Number 数量 | 6 | ||
Flow rate 排气速度 | 90m3/hr (×6) | ||
Motor power 电机功率 | 3.7Kw (×3) | ||
5 | Mechanical booster pump 罗茨泵 | ||
Brand 品牌 | BAOSI | ||
Model 型号 | BSJ300L | ||
Type 方式 | Roots 机械式 | ||
Number 数量 | 1 | ||
Flow rate 抽气速度 | 1000m3/hr (×2) | ||
Motor power 电机功率 | 3.7KW (×2) | ||
6 | Anti-suction valve 真空防倒吸阀 | Included 有 | |
Control System 控制系统 | |||
1 | Software 软件 | 欣谕-5000（可随时免费升级） | |
Automatic 自动 | Included 有 | ||
Manual 手动 | Included 有 | ||
2 | PLC+PC 可编程控制器 | Omron | |
3 | Industrial personal Computer 工控机 | 品牌平板电脑 | |
4 | Vacuum gauge 真空探头 | ZHVAC | |
5 | Temperature probe 温度探头 | Pt100 | |
6 | Pressure transducer 压力变送器 | GK | |
7 | Breaker 空开 | schneider | |
8 | Contactor 接触器 | schneider | |
9
| Relay 继电器 | schneider | |
Safety System 安全系统 | |||
1 | Vacuum failure protection 真空失败保护 | Included 有 | |
2 | Temperature failure protection 温度失败保护 | Included 有 | |
3 | Compressor protection 压缩机保护 | Included 有 | |
4 | Other motors protection 其它电机保护 | Included 有 | |
5 | Interlock protection 连锁保护 | Included 有 | |
Utility Requirement (approx.) 公用工程消耗(大约) | |||
1 | Electricity - total electrical load 总装机功率 | 270kW (380V, 50Hz, 3Phase, 5Wire) | |
2 | Cooling water for refrigerant cooling 用于制冷系统的冷却水 | 60m3/hr (1.5≤P≤2bar, T≤25°C) | |